A Comparison of Co- Current and Counter- Current Modes of Operation for Dual- Type Industrial Fischer- Tropsch Reactor

سال انتشار: 1387
نوع سند: مقاله کنفرانسی
زبان: انگلیسی
مشاهده: 2,278

فایل این مقاله در 16 صفحه با فرمت PDF قابل دریافت می باشد

استخراج به نرم افزارهای پژوهشی:

لینک ثابت به این مقاله:

شناسه ملی سند علمی:

NICEC12_086

تاریخ نمایه سازی: 30 شهریور 1387

چکیده مقاله:

The present work investigates a dual catalyst bed concept for industrial Fischer- Tropsch synthesis at dynamic condition for the first time. In the dual-type reactor, two catalyst beds instead of one is developed for Fischer- Tropsch synthesis. For simulation purposed, a heterogeneous one-dimensional model is used to analyze and compare the effect of co- current and counter- current flow pattern on performance of reactor. In the co-current mode, feed gas is entered into the tubes of the second reactor in the same direction with the reacting gas stream in shell side while in the counter-current mode the gas streams are in the opposite direction. The proposed model was investigated against measured process data of Fischer- Tropsch plant and a good agreement was achieved. Simulation results for both modes have been compared in terms of temperature, activity and methane mole fraction and shown that co-current mode operates with lower conversion in comparison with counter-current.

نویسندگان

M. R. Rahimpour

Chemical Engineering Department, Shiraz University

M Tajmiri

Chemical Engineering Department, Shiraz University

مراجع و منابع این مقاله:

لیست زیر مراجع و منابع استفاده شده در این مقاله را نمایش می دهد. این مراجع به صورت کاملا ماشینی و بر اساس هوش مصنوعی استخراج شده اند و لذا ممکن است دارای اشکالاتی باشند که به مرور زمان دقت استخراج این محتوا افزایش می یابد. مراجعی که مقالات مربوط به آنها در سیویلیکا نمایه شده و پیدا شده اند، به خود مقاله لینک شده اند :
  • Rahimpour, M. R., S. Satar, M. Baniadam, J. Fathikalajahi, ، ...
  • Aria Sasol Company, Operating data sheets of GTL plant, Asalooyeh, ...
  • _ (2003). "HIeterogeneous Modeig for Fixed- Bed Fische- Tropsch Synthesis ...
  • Zimmerman, W. H., Rossin, J. A., & Bukur, D. B. ...
  • Anderson, R B., Seligman, J. F., Kelly, R., & Elliot, ...
  • Eliason, S. A, B artholomoew, C. H. (1999).، Reaction and ...
  • I. Lavik, M. Hillestad, T. Hertzberg, Long term dynamic optimization ...
  • L. Hanken, Optimization of methanol reactor, Master's thesis, The Norwegian ...
  • E. L. Cussler, Diffusion, Mass Transfer in Fluid Systems, Cambridge ...
  • C. R. Wilke, Chem. Eng. Progress, 45, p.218, 1949. ...
  • R. C. Reid, T. K. Sherwood and J. Prausnitz, The ...
  • F. Hartig, F. J. Keil, Large-Scale Spherical Fixed- Bed Reactor: ...
  • J. M. Smith, Chemical Engineering Kinetics, McGraw-Hill, New York, 1980. ...
  • J. P. Holman, Heat Transfer, Mc Graw-Hill, New York, 1989. ...
  • نمایش کامل مراجع